TM 9-6115-659-13&P
CHAPTER 5
DIRECT SUPPORT MAINTENANCE
Subject Index
Page
Section I
Repair Parts; Special Tools; Test, Measurement, and Diagnostic Equipment
(TMDE); and Support Equipment ................................................................................... 5-2
5-1
Common Tools and Equipment ...................................................................................... 5-2
5-2
Special Tools, TMDE, and Support Equipment .............................................................. 5-2
5-3
Repair Parts.................................................................................................................... 5-2
Section II Troubleshooting............................................................................................................................... 5-3
5-4
General ........................................................................................................................... 5-3
Section III Maintenance Procedures ............................................................................................................... 5-8
5-5
General ........................................................................................................................... 5-8
5-6
Generator Set Maintenance............................................................................................ 5-8
5-7
Electrical Leads W3-W8 Maintenance ........................................................................... 5-16
5-8
Switch Box Harness W9 Maintenance ........................................................................... 5-18
5-9
Relay Board Harness W1l Maintenance ......................................................................... 5-24
5-10
Output Connector Harness W10 Maintenance ............................................................... 5-26
5-11
Relays K3-K6 Maintenance ............................................................................................ 5-29
5-12
Permissive Paralleling Relay Maintenance..................................................................... 5-31
5-13
Contractors K1 and K2 Maintenance.............................................................................. 5-33
5-14
Resistors R1-R3 Maintenance........................................................................................ 5-36
5-15
Capacitors C1-C4 Maintenance...................................................................................... 5-38
5-16
Diodes CR1-CR4 Maintenance ...................................................................................... 5-39
5-16.1
PU-797A and AN/MJQ-35A Floor and Fender Replacement ......................................... 5-40
5-17
Trailer Fender Repair...................................................................................................... 5-41
5-18
AN/MJQ-35 Generator Mounting Rail Maintenance ....................................................... 5-41
5-19
AN/MJQ-36 Generator Mounting Rail Maintenance ....................................................... 5-43
5-20
PU-797 Generator Mounting Rail Maintenance.............................................................. 5-45
5-21
AN/MJQ-35 Trailer Lifting Bracket Maintenance ............................................................ 5-47
5-22
PU-797A and AN/MJQ-35A Generator Mounting Rail Replacement.............................. 5-51
5-23
High Mobility Trailer Rear Leveling-Support Jack Maintenance..................................... 5-53
Change 2 5-1
