LO 5-6115-458-12
*The time specified is the time required to perform all services
at the particular interval (On-condition or hard time).
*TOTAL TASK - HR
*TOTAL TASK - HR
INTERVAL
TASK - HR
INTERVAL
TASK - HR
8
0.1
50H or 60D
0.6
100
1.2
1000
1.0
- KEY -
EXPECTED TEMPERATURES
ABOVE +32 F
+40 F TO -10 F
0 F TO -65 F
LUBRICANTS
CAPACITY
INTERVALS
(ABOVE 0 C)
(+5 C TO -23 C)
(-18 C TO -50 C)
LUBRICATING OIL,
OE/HDO
(MIL-L-2104D)
Engine
Engine Crankcase
Intervals
OE/HDO 30
OE/HDO 10
with Filters
48 qts (45.6L)
given are
OR
OR
OEA
Oil Can points
in hours of
LUBRICATING OIL,
OEA
OE/HDO 15-40
OE/HDO 15-40
normal
(MIL-H-46167)
Engine, Subzero
operation
HYDRAULIC FLUID
OHA
(MIL-H-5606B)
Hydraulic Tank
Filters and Lines
8 qts (7.6L)
ALL TEMPERATURES
NOTES:
1. FOR OPERATION OF EQUIPMENT IN PROTRACTED
6. CRANKCASE OIL. A sample of the oil shall be sent
COLD TEMPERATURES BELOW -10 F (-23 ). Remove
to an AOAP laboratory for analysis at an interval of 50
hours or 60 days. Refer to TB 43-0210 for sampling
lubricants prescribed in the key for temperatures above
requirements.
-10 F (-23 C). Clean parts with dry-cleaning SOLVENT
(SD), type II or equivalent. Lubricate with lubricants
7. When AOAP laboratory support is not available,
specified in the key for temperatures 0 F to -65 F.
drain and refill crankcase oil at 300 hours or 6 months.
2. OIL CAN POINTS. Every 100 hours lubricate hinges,
Copy of this Lubrication Order will remain with the equipment
latches, control linkages, and all exposed adjusting
at all times; instructions contained herein are mandatory.
threads with OE-HDO.
3. Crankcase oil level may be determined while engine
By Order of the Secretary of the Army;
is running.
4. ENGINE OIL FILTER. Every 300 hours remove filter
element, clean housing, install new element, fill
CARL. E. VUONO
crankcase, operate engine for 5 minutes, and check
General, United States Army
housing for leaks, Shut down engine, check crankcase oil
Chief of Staff
level, and bring to full mark. Oil filter replacement
Official:
interval shall aline with on-condition AOAP or hard time
5. SET DIFFERENCES. Used on precise generator sets
R. L. DILWORTH
only.
Brigadier General, United States Army
The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-25A,
Operator and Unit Maintenance requirements for Generator
Set, 120/208V, 240/416V, 200 KW, 3 PH, 4 Wire (MEP-009A,
MEP-108A).
020612-000
LO 5-6115-458-12
U.S. GOVERNMENT PRINTING OFFICE : 1999 O - 454-099 (80448)
CARD 2 OF 2
